梦之龙游乐青虫滑车使用说明书（二）_郑州市梦之龙游乐设备制造有限公司

梦之龙游乐青虫滑车使用说明书（二）

浏览次数: 998次
发布时间: 2018-06-12

导读： “青虫滑车”又叫果虫滑车，它是童趣园游乐根据市场需要开发研制的一款轨道类游乐设备，此款设备主体是一条大青虫造型，适用于游乐场、广场、公园等各类室内外游乐场所，

五、青虫滑车安全注意事项：Safety precautions:

1、用户供给游艺机的电源应有漏电开关保护，且电源插座中的接地极必须与保护接地线（网）可靠连接，各组电气导线的连接必须由专业电气安装人员操作。

The power supply should have leakage protection , And the grounding in the power supply socket must connect with the protect ground wire (Network) . Each group of electrical wire connection must be operated by professional electrical installation personnel. The connecting of electrical conductor should operated by professional Electrical installation personnel

2、电控柜金属外壳，机架必须与保护接地线可靠连接。（接地电阻≤10Ω）

The shell of control , frame must connect with Grounding wire.(The grounding resistance< 10Ω)

3、游艺机安全停稳后，儿童才能进入或离开机舱。

After the equipment stop well, then Kids can be allow to enter or left cabin.

4、座舱内的乘客未坐好，不允许启动游艺机。

Before passenger sit down well, don’t allow to start the equipment.

5、游艺机在运行时，严禁任何人进入围栏内，严禁乘客离开座舱。

When the equipment is running, do not allow anyone to enter the fence, do not allow passenger leave cabin.

6、游艺机运行不正常或不能自动停机，应立即关掉电源总开关，或拨掉电源插头。

The equipment is not running properly, or can not stop automatic, should turn off the power switch, or pull out the power plugs.

7、在检修游艺机期间，必须事先将电源切断。

During the overhaul of amusement machine, Power supply must be cut off in advance

8、更换保险管时，必须选用与原规格一致的保险管。

Replacement of the insured, Must choose the same as the original specifications of the insurance tube

9、潮湿大风雷雨天气不可运行设备。

The equipment can not use in Wet and windy thunderstorm weather.

六、青虫滑车保养与维修：Maintenance and repair

1、应经常保持游艺机内，外的清洁。

Should always keep the game machine inside and outside the clean.

2、游艺机投入使用前，要检查整机各件的情况，对紧固件要认真检查，以后要定期或不定期的检查，紧固。

Before entering the game machine, to check the situation of the machine parts, fasteners to be carefully checked, after regular or irregular inspection, fastening

3、定期或不定期检查。

Regular or irregular inspection

4、视使用情况，对齿轮，轴承定期或不定期加注润滑脂。

Depending on the use of the gear, bearing periodic or irregularly filling grease.

5、新游艺机使用一段时间后，应检查。

After a period of use of new recreational machines should be checked

6、若游艺机长时间不投入使用，则至少每月启动运行4-8小时，使游艺机的机械，电气系统能保持良好的工作状态。

7、 If the game machine is not put into use for a long time, at least monthly start running 4-8 hours, so that the game machine mechanical and electrical systems can maintain a good working condition

8、电控柜要作好防雨，防潮，防浸措施。

Electric control cabinet to do a good job of rain, moisture, dipping measures.

七、青虫滑车故障及检修：

故障现象 Fault analysis	故障分析 Fault analysis	检修排除方法 Troubleshooting methods
电动机不能启动 Motor can not be started	电动机的离心开关合不上，或位置偏移，不清洁致使接触不良。 2. Centrifugal switch of motor can not closed or Position offset . Uncleanness makes bad connection	检查离心开关，调整位置，清洁触头。 Check centrifugal switch Adjust switch position Clean the connection
	电动机极掌与转子间有线圈扎线熔断。 There is coil Fuse between the Motor pole palm and rotor	将断口处理好。 Repair the fracture
	各轴承，传动件失油，内有污物，轴承损坏等导致转动运转不灵。 1.Bearings and driving mediums lost oil 2.There is dirt inside 3.Bearings failure	对轴承，转动件等清洗，加油，甚至更换轴承。 1.Clean the bearings and driving mediums 2. Add oil. 3..Change bearings
	电容击穿 Capacitor breakdown	更换电容 Change the capacitor
	电容击穿 Capacitor breakdown	修理机械传动部分。 Repair the transmission parts
启动后，游艺机不能正常运行 The machine can’t work when press the start button	过流使开关C45N自动切断电源 The overcurrent switch C45N stop the power supply automatic	检查电动机和过流开关。 Check the electromotor and the overcurrent switch
游艺机不能在定时控制时间内自动停止运行 The machine can’t stop at the adjusted time	接插件松动， The connector is loose	检查各接插点。 Check all the connector
	定时数值开关接触不良，或定时电路板有故障。 The switch of timing set is bad connected or the circuit board don’t work well	检修或更换 Check and change